The Ariens Deluxe 24 Model 921045 is a 24-inch two-stage snow thrower powered by a robust engine designed for heavy-duty snow removal. This manual covers the engine specifications, operation, maintenance, safety procedures, and troubleshooting specific to this model. Below are key sections for safety, features, operation, maintenance, and troubleshooting.
Key components: Engine, recoil starter, fuel tank, oil fill cap, spark plug, air filter, throttle control, choke control.
| Feature | Description |
|---|---|
| Engine Type | 4-cycle, single-cylinder, overhead valve (OHV) |
| Displacement | 208 cc (cubic centimeters) |
| Fuel Tank Capacity | 0.9 gallons (3.4 liters) |
| Oil Capacity | 20 oz (0.6 liters) |
| Starting System | Recoil (pull-start) |
| Ignition System | Electronic (solid-state) |
| Air Cleaner | Dual-element (foam and paper) |
| Spark Plug | Standard resistor type (gap: 0.030 in / 0.76 mm) |
| Governor | Mechanical, auto-adjusting |
| Engine Shut-off | Ignition key/switch |
Read all instructions before operating. Wear appropriate safety gear.
WARNING! Gasoline is flammable; store in approved container away from ignition sources. Never operate in enclosed area.
Locate all controls before starting. Engine Panel: Ignition key/switch, choke lever, throttle control, primer bulb, recoil starter handle.
Operation: Insert key, set choke to FULL for cold start, press primer bulb 3 times, pull recoil starter. Adjust throttle to desired speed. Use choke to OFF after engine warms.
Maintenance Points: Oil fill/drain plug, air filter cover, spark plug wire, fuel shut-off valve (if equipped).
Starting (Cold Engine):
Stopping:
Tip: For hot restart, choke not needed; may require slight throttle.
Regular maintenance ensures long engine life.
| Interval | Task |
|---|---|
| Before each use | Check oil level; inspect for leaks; check air filter |
| First 5 hours | Change oil (break-in period) |
| Every 25 hours | Change oil; check spark plug; clean air filter |
| Every 50 hours | Replace spark plug; inspect fuel filter |
| Every 100 hours | Clean carburetor; check valve clearance |
| Season end | Drain fuel or add stabilizer; change oil |
CAUTION! Always disconnect spark plug before servicing.
Oil: Use 4-stroke engine oil. Capacity: 20 oz (0.6 L). Check dipstick; fill to FULL mark.
Fuel: Use fresh unleaded gasoline (87 octane min). Do not use gasoline with more than 10% ethanol. Add fuel stabilizer if storing over 30 days.
WARNING! Never mix oil with gasoline; this is a 4-cycle engine.
| Symptom | Possible Cause | Corrective Action |
|---|---|---|
| Engine won't start | No fuel; old gasoline; clogged fuel line; bad spark plug | Check fuel; replace if stale; clean fuel line; check/replace spark plug. |
| Hard starting | Choke not set; primer not used; low compression | Set choke FULL; prime 3 times; check compression (may need service). |
| Engine runs rough | Dirty air filter; water in fuel; carburetor issue | Clean/replace air filter; drain fuel tank; clean carburetor. |
| Loss of power | Clogged fuel filter; old oil; governor issue | Replace fuel filter; change oil; check governor linkage. |
| Excessive smoke | Overfilled oil; worn piston rings; wrong oil type | Drain excess oil; check rings; use correct oil. |
| Engine overheats | Low oil; dirty cooling fins; running at high load | Check oil level; clean fins; reduce load. |
Reset: None required; refer to service if issues persist.
Prepare engine for storage to prevent damage.
CAUTION! Never store with fuel in tank unless stabilized; fuel degrades over time.
Ariens provides limited warranty for residential use. Refer to warranty card for details. Engine components covered for defects in materials/workmanship. For support, contact Ariens Customer Service at 1-800-678-9443 or visit www.ariens.com. Have model number (921045) ready.
Copyright © 2025 Ariens Company. All rights reserved. Ariens and Deluxe are trademarks of Ariens Company.